Stright Pipe or Cat replacemnt?
#1
Member
Thread Starter
Join Date: Aug 2014
Location: Metro Detroit
Posts: 101
Likes: 0
Received 0 Likes
on
0 Posts
Year: 1995
Model: Cherokee
Engine: 4.0
Stright Pipe or Cat replacemnt?
I got a 95 xj. My cat has a hole so im getting it replaced. My dad told me I can just stright pipe it but ik wondering will i have worse gas milalge when i do. I live in Michigan so we have bo inspection laws. Any suggestions?
#3
If you're okay with the CEL always being on then you can straight pipe the whole thing. You'll throw your o2 sensors out of whack which in turn will affect your performance and gas mileage. Not recommended.
#4
CF Veteran
Join Date: Jan 2014
Location: District of Columbia
Posts: 1,338
Received 285 Likes
on
215 Posts
Year: 1998
Model: Cherokee (XJ)
Engine: 4.0
While eliminating your cat is against both forum rules and federal law, I'd just like to clarify the previous poster who said it'll throw your O2 sensor readings off and mess with driveability. The upstream O2 sensor gives feedback to the ECU, and that's not affected by the cat being in place or not (assuming it's not clogged, of course). The downstream O2 sensor monitors cat performance and will throw a CEL if you eliminate the cat or it's otherwise not performing correctly.
Again, don't eliminate it.
Again, don't eliminate it.
#5
CF Veteran
How much would you actually gain, powerwise? Because a replacement cat is really cheap. I put a cat on mine, even though being in England and running on LPG I could have got away with a straight pipe. I just couldn't see the point.
#6
CF Veteran
Join Date: Feb 2010
Location: Oroville, CA
Posts: 12,367
Likes: 0
Received 22 Likes
on
21 Posts
Year: 1995
Model: Grand Cherokee
Engine: 4.0 with all of the noise and clatter
No downstream O2 on a 95 to set a code, but you shouldn't run without a catalytic converter. The power gain isn't real noticeable.
Trending Topics
#8
CF Veteran
Join Date: Feb 2012
Location: Hamburg, NY
Posts: 1,258
Likes: 0
Received 0 Likes
on
0 Posts
Year: 2001
Model: Cherokee
See about an aftermarket cat, they're not much money & you'll probably hate driving without a cat. a buddy did (years ago) & his car was almost unbearable to ride in or drive near.
Buy a Cat & toss it in.
Buy a Cat & toss it in.
#9
Senior Member
Join Date: Sep 2014
Posts: 739
Likes: 0
Received 5 Likes
on
5 Posts
Year: 2012
Model: Grand Cherokee (WK)
Engine: 3.6 V6
I am in the same boat as the OP, except that my cat was causing a loss of power when driving it especially up hills (paved). This past week one morning before work I cut the cat off, from the end of the up pipe all the way back and it sounds like a tank but my jeep is running much better power wise. I just placed my order on amazon for the head pipe, new O2 sensor, cat, tail pipe, muffler, clamps and hangers for about $260. These were mostly walker pipes and I may have get some welding done to it but it won't be much.
#10
CF Veteran
Join Date: Jan 2015
Location: Oregon Coast
Posts: 1,508
Likes: 0
Received 5 Likes
on
5 Posts
Year: 1999
Model: Cherokee
Engine: 4.0L I6
I am in the same boat as the OP, except that my cat was causing a loss of power when driving it especially up hills (paved). This past week one morning before work I cut the cat off, from the end of the up pipe all the way back and it sounds like a tank but my jeep is running much better power wise. I just placed my order on amazon for the head pipe, new O2 sensor, cat, tail pipe, muffler, clamps and hangers for about $260. These were mostly walker pipes and I may have get some welding done to it but it won't be much.
#11
Senior Member
Join Date: Sep 2014
Posts: 739
Likes: 0
Received 5 Likes
on
5 Posts
Year: 2012
Model: Grand Cherokee (WK)
Engine: 3.6 V6
I ordered the clamps to go with it but on the previous setup someone welded a pipe onto the cat to extend it for some reason. If I need to do something similar I will but I don't think it will come to that or so I hope. Thanks for the input too.
#12
Senior Member
Join Date: Sep 2014
Location: Saginaw Mi area
Posts: 580
Likes: 0
Received 0 Likes
on
0 Posts
Year: 1994
Model: Cherokee
Engine: 4.0
Not sure about the Jeep engine operating system, but on some GM cars, the engine runs a bit lean without the converter, so it's best to replace it. I'm a believer in keeping our air clean too !!
#13
Senior Member
Join Date: Mar 2012
Location: Racine, WI
Posts: 974
Likes: 0
Received 12 Likes
on
9 Posts
Year: 1997
Model: Cherokee
Engine: 4.0
Sell your original cat to a scrapper. Depending on your area, it is worth $30-50 (assuming it is a factory cat).
Then buy a new cat from Performance-curve.com. They have great cats for as low as $60-70, maybe less.
Replace the cat. It is the law, and we'll all have cleaner air to breath when you do.
Then buy a new cat from Performance-curve.com. They have great cats for as low as $60-70, maybe less.
Replace the cat. It is the law, and we'll all have cleaner air to breath when you do.
#14
Senior Member
Join Date: Sep 2014
Posts: 739
Likes: 0
Received 5 Likes
on
5 Posts
Year: 2012
Model: Grand Cherokee (WK)
Engine: 3.6 V6
Make sure you can take the cat to a scrap yard, most want proof that you replace these for a living since they are a popular item to steal for the metals inside of them. I called my local scrapper and they won't even touch them and found another online that will but I would need a business license to take it there.
#15
CF Veteran
Join Date: Jun 2014
Location: PA
Posts: 1,052
Likes: 0
Received 0 Likes
on
0 Posts
Year: 1994
Model: Cherokee
Engine: 4.0 HO
[QUOTE=caronaxtr;3141066]See about an aftermarket cat, they're not much money & you'll probably hate driving without a cat. a buddy did (years ago) & his car was almost unbearable to ride in or drive near.
Why?
Was it that loud?did he have a muffler installed?
Why?
Was it that loud?did he have a muffler installed?