88whitecomanche

Got a # to call?

Outlaw Star

I'll grab it for you tomorrow, I'm a little medicated right now..

88whitecomanche

So 1 step forward 3 steps back....

New driveshaft made and installed....
But leaking oil I "think" from the mating surface of the transmission and transfer case...unless I overfilled it? I put 5 quarts...too much?

freegdr

You resaled both units b4 install ?

88whitecomanche

Reseal?
I read that they don't have to be sealed...
Just attach them together and bolt it down....



And I did add to much oil to the ax15 I added 5 quarts and it was suppose to be 3.5 quarts...

freegdr

There front and rear seals on all trannys and transfer cases. You have this ....http://www.jeep4x4center.com/cherokee/menu.htm

88whitecomanche

It's the transmission for sure because I put 5w-30 motor oil in there and at fluid in the transfer case....

freegdr

Omix-Ada AX15 Oil Seal For Front Bearing Retainer For 1989-99 Jeep Wrangler YJ, TJ & Cherokee XJ.......https://www.justjeeps.com/product.php?productid=36815

freegdr

Morris.....http://www.jeep4x4center.com/jeep-tr...aisin-ax15.htm .................NO...20

freegdr

You deff put to much oil in causing a leak. Think though if oil will come out water will deff get in.

88whitecomanche

I did replace #20....
But #48 I didn't....I'm going to let it leak until it's drops to level

freegdr

Why not Just remove fill plug ? Also you didnt use syncro mesh you used motor oil ?

http://www.pennzoil.com/other-car-pr...mission-fluid/

freegdr

One other question your rear shaft looks to long. Or is it the angle .

SergeK

Starter went out this week on the way to work. Had to get AAA to come out. Guy tapped it with a hammer and there she went. For some reason I thought it was the battery. Was able to make it home, got a starter on the way. Replaced it the other night. Wasnt too bad. Only thing that slowed me down was the dark and the damn mosquitos. They were BRUTAL.

Now with all this rain, I am noticing that my drivers door is leaking even though the weather seal looks good? Should I just go ahead and replace?

Also, sometimes my AC is warm. Usually it is cool, not cold. Only time its cold is at night or when its raining. Should I just check the level?

And last thing, is there a shop around here or someone who knows XJ's that wouldnt mind looking over the suspension with me? I dont know much about these cars and am unsure of what to look for. I have a wobble between 55-75mph but it is not constant and comes and goes. I want to track that down and fix it before I do a lift.

88whitecomanche

No I didn't use any...most of the guys on Comanche forum just say to use 10w-30 motor oil...and I didnt it on my ax5 Either just straight motor oil....


It's the angle because shaft fits just about right